Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
X
5
 Source, Wholesome, No Spoilage
19
X
2
 Wash, rinse after: clean, proper temperature
2
X
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
X
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 50-100 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   pork 37, chicken 36, raw shrimp 37, rice 164, wonton 184, chicken 39, raw pork 40, bbq chicken 39, rice 200, gravy 40, seafood 182, egg drop 171
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  10/11/2011 Time In  1:15 PM Time Out  3:00 PM Sanitation Score  79 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  89  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*1  Observed the following food containers to be damaged to the extent in which the food product inside may be compromised Provide for all food products that have been compromised due to container damage to be either returned to supplier or destroyed. 750.100 Immediate/Onsite
*12  Observed an employee drink/drinking in the following location(s). Employee drink was stored on prep table. The consumption of food/drink shall be done in a designated area only. Employee drink was thrown away. 750.280 Immediate/Onsite
2  Observed the following food products to have improper/no labeling information. Nuts, salt etce were not labeled on dry storage shelves above warmers. Provide for all foods to have proper labeling information. 750.100 Next Inspection
8  Observed the following food products to be improperly stored. Eggs were stored too high in reach-in cooler. 2. Egg rolls & chicken did not have lids or plastic on them in refrigerators. Store under line in pan. 750.130 Next Inspection
15  Observed the following improper non-food contact surfaces. 1. Dish racks are warn & have been damaged. 2. Bottom of small prep table by dishwasher has rust built up on it. Remove rust from this shelf or replace table. 3. Seal gaskets have food debris in them. Provide for all non-food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.690 Next Inspection
19  Observed the wash water to be unclean in the three compartment sink. Provide for equipment and utensils to be thoroughly washed in the first compartment with a hot detergent solution that is kept clean. 750.820 Next Inspection
22  Observed the following food contact surfaces to be unclean. Interior of ice machine has mold growth on it. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. Grillhood has grease & debris on it. 2. Bottom of prep tables have food debris on them located on prep line. Clean and maintain Next Inspection
36  Observed the following floor areas to be unclean: 1. Floor under dishwasher has debris on it. 2. Floor under three compartment sink has black debris on it. 3. Floor under woks & fryer has food debris on it. 4. Floor in walk-in freezer has food debris on it. 5. Floor behind ice machine has debris on it. 6. Floor in dry storage area has debris on it. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
37  Observed the following wall/ceilings area(s) to be in poor repair: Wall has chipped pain & gypsum board. Repaint & repair wall in employee restroom. Provide for all walls and ceilings to be smooth, easily cleanable, non-absorbent, durable, and light colored and be maintained in good repair. 750.1210 Next Inspection
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  10/11/2011 Time In  1:15 PM Time Out  3:00 PM Sanitation Score  79 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  89  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  10/11/2011 Time In  1:15 PM Time Out  3:00 PM Sanitation Score  79 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  89